XL Airways Germany Flight 888T

Coordinates: 42°39′48″N 03°06′00″E / 42.66333°N 3.10000°E / 42.66333; 3.10000
From Wikipedia, the free encyclopedia

XL Airways Germany Flight 888T
D-AXLA, the aircraft involved in the accident
Accident
Date27 November 2008 (2008-11-27)
SummaryStalled and crashed during test flight
SiteMediterranean Sea, near Canet-en-Roussillon, France
42°39′48″N 03°06′00″E / 42.66333°N 3.10000°E / 42.66333; 3.10000
Aircraft
Aircraft typeAirbus A320-232
OperatorXL Airways Germany (due to be re-delivered to Air New Zealand)
IATA flight No.X4888T
ICAO flight No.GXL888T
Call signSTARDUST 888T
RegistrationD-AXLA (due to change to ZK-OJL)
Flight originPerpignan–Rivesaltes Airport
DestinationPerpignan–Rivesaltes Airport
Occupants7
Passengers5
Crew2
Fatalities7
Survivors0

XL Airways Germany Flight 888T (GXL888T)[1] was an acceptance flight for an Airbus A320 on 27 November 2008. The aircraft crashed into the Mediterranean Sea, 7 km (4.3 mi; 3.8 nmi) off Canet-en-Roussillon on the French coast, close to the Spanish border, killing all seven people on board.[2]

Background[edit]

Purpose of the test flight[edit]

The aircraft was on a flight test (or "acceptance flight") that had taken off from Perpignan–Rivesaltes Airport, made an overflight of Gaillac, and was flying back to Perpignan Airport approaching over the sea. The flight took place following light maintenance and repainting to Air New Zealand livery in preparation for its transfer from XL Airways Germany, which had been leasing the aircraft from Air New Zealand, the owner.[2]

Aircraft[edit]

On the day of the crash, D-AXLA had been recently repainted in Air New Zealand colours, and appeared similar to this Air New Zealand Airbus A320.

The aircraft involved was an Airbus A320-232, registered D-AXLA, manufactured in 2005, and assigned a manufacturer's serial number of 2500. It first flew on 30 June 2005, and was delivered to Air New Zealand's low-cost subsidiary Freedom Air with the registration ZK-OJL. Star XL German Airlines (as XL Airways Germany was named at the time) took delivery of the aircraft on 25 May 2006. The aircraft had been overhauled by a local French company located at the Perpignan–Rivesaltes Airport prior to its return off lease.[3] At the time of the crash it was due to be delivered back to Air New Zealand and re-registered as ZK-OJL.[4]

Passengers and crew[edit]

Seven people were on board, two Germans (the captain and first officer, from XL Airways) and five New Zealanders (one pilot, three aircraft engineers, and one member of the Civil Aviation Authority of New Zealand (CAA)).[5][6]

The captain was 51-year-old Norbert Käppel,[7] who had been with the airline since February 2006. He was the airline's air and ground operations manager, having previously held this position at Aero Lloyd. Käppel had logged a total of 12,709 flight hours, including 7,038 hours on the Airbus A320.[8]: 21–22 

The first officer was 58-year-old Theodor Ketzer,[7] who had been with the airline since April 2006 as an A320 first officer. He attempted to upgrade to an A320 captain in 2007, but dropped out of the programme for "personal reasons".[8] Ketzer had 11,660 flight hours, with 5,529 of them on the Airbus A320.[8]: 22–23 

The pilot from New Zealand was 52-year-old Brian Horrell, who had been with Air New Zealand since September 1986. He had been an Airbus A320 captain since 27 September 2004, and had 15,211 flight hours, including 2,078 hours on the Airbus A320. Horrell was seated in the cockpit jumpseat at the time of the accident. He did not speak nor understand German.[8]: 23–24 

The three aircraft engineers were 37-year-old Murray White, 49-year-old Michael Gyles,[9] and 35-year-old Noel Marsh.[8]: 24 [7] The member of the CAA was 58-year-old Jeremy Cook.[8]: 24 [7]

Accident[edit]

The aircraft departed Perpignan–Rivesaltes Airport at 14:44 UTC. The overflight at Gaillac was mostly normal. At 15:04, though, angle-of-attack sensor number 1 became blocked, and sensor number 2 became blocked two minutes later.[8]: 16 

At 15:33, the aircraft started back towards Perpignan Airport, but at 15:46 UTC during final approach, the aircraft suddenly disappeared from the radar screens.

The aircraft crashed into the Mediterranean Sea, 7 km (4.3 mi; 3.8 nmi) off the coast of Étang de Canet-Saint-Nazaire near Canet-en-Roussillon. All seven people on board were killed.[8]: 15–20 

Recovery[edit]

Two bodies were recovered within hours of the crash; the others were found during later weeks. The extent of shattering of the wreckage indicated that the crash occurred at high speed.[10] The crash area was declared a crime scene and the French justice system opened a manslaughter investigation.[10]

Investigation[edit]

The cockpit voice recorder (CVR) was quickly found and recovered, and on 30 November, divers recovered the second flight recorder–the flight data recorder (FDR)–and a third body, unidentified at the time. Although the CVR was damaged, experts said a good probability existed of recovering data from it.[11]

In late December, French investigators attempted to retrieve data from the CVR and FDR, but they could not be read. Usable data from the recorders was later recovered by Honeywell Aerospace in the United States.[12]

The investigators' interest focused on the air data inertial reference unit (ADIRU) following recent similar incidents involving Airbus A330s operated by Qantas, exhibiting sudden uncommanded manoeuvring (including Qantas Flight 72).[13] The investigation was led by the Bureau of Enquiry and Analysis for Civil Aviation Safety (BEA), with the participation of its counterparts from the German Federal Bureau of Aircraft Accident Investigation (BFU), the New Zealand Transport Accident Investigation Commission (TAIC),[14] and the United States National Transportation Safety Board (NTSB). Specialists from Airbus and from International Aero Engines (IAE, the manufacturer of the aircraft's engines), from XL Airways Germany (operator of the aircraft), and from Air New Zealand (the owner of the aircraft), were associated with the work of the technical investigation.[15]

Analysis of the data led to an interim finding that the crew lost control of the aircraft. The crew was not granted needed airspace to do their acceptance checklist of various test procedures, but they chose to conduct a number of the tests as they flew back to base. One of the tests that the crew unofficially fit into their flight was a test of low-speed flight, which they attempted after already dropping to a low altitude (rather than the normal 10,000 feet (3,000 m)), while descending through 3,000 feet (910 m) on full autopilot for a go-around. Landing gear was just extended when at 15:44:30 UTC the speed dropped from 136 to 99 knots (252 to 183 km/h; 157 to 114 mph) in 35 seconds. The stall warning sounded four times during violent manoeuvring to regain control. By 15:46:00, the warning had silenced as the aircraft regained speed in a rapid descent, but 6 seconds later, at 263 knots (487 km/h; 303 mph), the aircraft had only 340 feet (100 m) elevation and was 14° nose down. A second later, the aircraft crashed into the water.[16]

In September 2010, the BEA published its final report into the accident. One of the contributing causes was incorrect maintenance procedures, which allowed water to enter the angle-of-attack (AOA) sensors. During fuselage rinsing with water before painting, three days before the flight, the AOA sensors were unprotected. As specified in the Structure Repair Manual by Airbus, fitting a protection device on AOA sensors before these tasks is mandatory.[8]: 56, 95  The water was able to penetrate inside the sensor bodies, then froze in flight, rendering two of three of the sensors inoperative, thus removing the protection they normally provided in the aircraft's flight management system.

The primary cause of the accident was that the crew attempted an improvised test of the AOA warning system, not knowing that it was not functioning properly due to the inoperative sensors. They also disregarded the proper speed limits for the tests they were performing, resulting in a stall.

The aircraft's computers received conflicting information from the three AOA sensors. The aircraft computer system's programming logic had been designed to reject one sensor value if it deviated significantly from the other two sensor values. In this specific case, this programming logic led to the rejection of the correct value from the one operative AOA sensor, and to the acceptance of the two consistent, but wrong, values from the two inoperative sensors. This resulted in the system's stall-protection functions responding incorrectly to the stall, making the situation worse, instead of better. In addition, the pilots also failed to recover from an aerodynamic stall in a manual mode in which the stabilizer had to be set to an up position to trim the aircraft. Since the stick was applied only forward, the aircraft did not trim itself because it was switched to full manual mode. Seconds later, the plane crashed into the sea.

Moreover, the stall warning in normal law was not possible. The stall warning function, though, was still available, and was triggered during the last phase of the flight.[17]

Five safety recommendations were made following examination of the particulars of the crash. To improve requirements for planning and procedures of non-revenue flights, to close a loophole pertaining to equipment qualification discovered during the investigation (but which did not impact the events as transpired), to undertake a safety study of certification standards for flight control reconfiguration warning systems, and to re-evaluate recommended approach-to-stall techniques and training for all types of modern airplanes.[8]

Dramatisation[edit]

The story of the accident was featured on the 13th season of Canadian television show Mayday, an episode entitled "Imperfect Pitch".[17]

See also[edit]

References[edit]

  1. ^ Hradecky, Simon (27 November 2008). "Crash: Air New Zealand A320 near Perpignan on Nov 27th 2008, impacted Mediterranean Sea". The Aviation Herald.
  2. ^ a b Ranter, Harro. "ASN Aircraft accident Airbus A320-232 D-AXLA Canet-Plage". aviation-safety.net. Aviation Safety Network. Retrieved 19 November 2019.
  3. ^ "Seas scoured after Airbus crash". BBC News. 28 November 2008.
  4. ^ "XL Airways Germany D-AXLA (Airbus A320 - MSN 2500) (Ex ZK-OJL )". www.airfleets.net. Airfleets aviation. Retrieved 19 November 2019.
  5. ^ "Airbus A320 crashes into sea off France". CNN. 28 November 2008.
  6. ^ "No hope of survivors in New Zealand jet crash off France: official". Agence France Press. 27 November 2008.
  7. ^ a b c d Field, Catherine (27 February 2009). "Germans killed in Air NZ disaster finally named". The New Zealand Herald. Retrieved 1 December 2023.
  8. ^ a b c d e f g h i j "Accident on 27 November 2008 off the coast of Canet-Plage (66) to the Airbus A320-232 registered D-AXLA operated by XL Airways Germany" (PDF). Bureau of Enquiry and Analysis for Civil Aviation Safety. Archived (PDF) from the original on 21 July 2011. Retrieved 16 September 2010.
  9. ^ "Victims named in Air NZ plane crash". Stuff. 31 January 2009. Retrieved 26 December 2021.
  10. ^ a b "Third body, second black box recovered". Fairfax Media. 2 December 2008. Retrieved 2 December 2008.
  11. ^ Field, Catherine (2 December 2008). "Air NZ crash: Damaged black box will give answers – investigator". The New Zealand Herald. Retrieved 2 December 2008.
  12. ^ Field, Catherine (9 January 2009). "Air NZ hopeful black box data will provide clue to crash". The New Zealand Herald. Retrieved 9 January 2009.
  13. ^ "Investigation's Slow Pace 'Troublesome'". Aero-News Network. 29 December 2008.
  14. ^ "Ao-2008-008 | Taic".
  15. ^ "NTSB preliminary record". www.ntsb.gov. National Transportation Safety Board. DCA09RA013. Retrieved 6 December 2019.
  16. ^ Accident on approach to Perpignan 2008 – Interim report (PDF). Bureau of Enquiry and Analysis for Civil Aviation Safety. 24 February 2009. pp. 9–10, 19–20, 31. ISBN 978-2-11-098614-6.
  17. ^ a b "Imperfect Pitch." Mayday [documentary TV series].

External links[edit]

Bureau of Enquiry and Analysis for Civil Aviation Safety

Retrieved from "https://en.wikipedia.org/w/index.php?title=XL_Airways_Germany_Flight_888T&oldid=1215083548"